Page 1 of 1
What happened? Bike not starting after two batteries
Posted: Wed Apr 10, 2024 9:41 am
by Mikekkim
So I started my 1994 vs 800 after winter and first day seem fine. That was yesterday. Today I tried starting it this morning (next day) and it cranked but then quit - won’t crank. So I put in a new battery. Rode it a few miles, parked, then tried starting again and cranked once then died and now won’t crank. There batteries were in trickle chargers . What happened?
Re: What happened? Bike not starting after two batteries
Posted: Wed Apr 10, 2024 10:09 am
by navigator
load test both batteries
jumper the clutch safety switch...it may be intermittent.
check the connections at the ends of all the cables...sand them down to bare metal.
check the ground cable where it attaches to the engine above the oil fill cap.
try jumping the two big lugs on the starter solenoid with a screwdriver...under the left side cover, be sure you are in neutral.
Re: What happened? Bike not starting after two batteries
Posted: Wed Apr 10, 2024 4:22 pm
by sgtcall
Welcome!
Here are a couple of things to check out.
INTRUDER MANUALS AND INFORMATION
viewtopic.php?f=19&t=14168
POSTING PICTURES ON INTRUDERS ALERT
viewtopic.php?f=19&t=13992
Re: What happened? Bike not starting after two batteries
Posted: Wed Apr 10, 2024 5:41 pm
by hillsy v2
sgt - what about star washers?
Re: What happened? Bike not starting after two batteries
Posted: Wed Apr 10, 2024 6:19 pm
by sgtcall
hillsy v2 wrote: ↑Wed Apr 10, 2024 5:41 pm
sgt - what about star washers?
That comes later.